爐子效率 的英文怎麼說
中文拼音 [lúzixiàolǜ]
爐子效率
英文
furnace efficiency-
Although arc spraying has the advantages of high deposition efficiency and low cost, only electrically conductive wire materials can be adopted for arc spraying. the quality of coatings produced with plasma spraying and hvof is high, but large volume of plasma spraying equipment makes it difficult to be used on site, and the high investment of equipment, the large consumption in fuel and high cost prevent from spreading of hvof
雖然電弧噴塗的效率高、成本低，但它僅適用於具有導電性的線材噴塗：等離子噴塗及超音速噴塗制備的塗層質量高，但等離子噴塗設備龐大，不適用於鍋爐現場噴塗；超音速火焰噴塗設備昂貴、耗氣量大、塗層成本高，從而限制了它的推廣。Abstract : the causes for low efficiency of the heater in no. 2 crude unit of jpc refinery are described and analyzed including water leaking of steam soot blower, dew point corrosion caused by steam, soot deposits in convection chamber owning to poor soot blowing, high flue gas temperature, no heat recovery of flue gas, and poor performance of insulation lining, etc. by using sonic soot removing system, flue gas recovery system, spray coating of fiber and rock wool, as well as adjustment of flow scheme accordingly in the technical revamping. the dew point corrosion is completely eliminated, the insulation performance is improved, the heat loss is reduced by 1. 25 %, the flue gas temperature is reduced to about 170, and the heater efficiency is increased from 83 % to more than 90 %
文摘:分析了金陵石油化工公司煉油廠二套常減壓裝置加熱爐存在的因蒸汽吹灰器漏水，蒸汽引起露點腐蝕及吹灰效果差造成對流室積灰，排煙溫度高，煙氣熱量未回收利用以及爐子保溫襯里效果差等問題，提出採用聲波除灰系統、煙氣回收系統、纖維噴塗和巖棉噴塗及相應的流程調整等改造措施.測定結果表明，本次技術改造解決了因蒸汽吹灰器漏水所造成的露點腐蝕問題，提高了保溫效果，減少散熱損失1 . 25 % ，排煙溫度降至170左右，裝置的爐效率由83 %左右提高到90 %以上The causes for low efficiency of the heater in no. 2 crude unit of jpc refinery are described and analyzed including water leaking of steam soot blower, dew point corrosion caused by steam, soot deposits in convection chamber owning to poor soot blowing, high flue gas temperature, no heat recovery of flue gas, and poor performance of insulation lining, etc. by using sonic soot removing system, flue gas recovery system, spray coating of fiber and rock wool, as well as adjustment of flow scheme accordingly in the technical revamping. the dew point corrosion is completely eliminated, the insulation performance is improved, the heat loss is reduced by 1. 25 %, the flue gas temperature is reduced to about 170, and the heater efficiency is increased from 83 % to more than 90 %
分析了金陵石油化工公司煉油廠二套常減壓裝置加熱爐存在的因蒸汽吹灰器漏水，蒸汽引起露點腐蝕及吹灰效果差造成對流室積灰，排煙溫度高，煙氣熱量未回收利用以及爐子保溫襯里效果差等問題，提出採用聲波除灰系統、煙氣回收系統、纖維噴塗和巖棉噴塗及相應的流程調整等改造措施.測定結果表明，本次技術改造解決了因蒸汽吹灰器漏水所造成的露點腐蝕問題，提高了保溫效果，減少散熱損失1 . 25 % ，排煙溫度降至170左右，裝置的爐效率由83 %左右提高到90 %以上Thus clean factor has good adaptability to boiler load, coal quality, excess air coefficient, working medium flow, and boiler efficiency etc. the calculated result gained by inputting the data of history database of the object boiler validates the correctness and adaptability to boiler load of clean factor model
基於穩態傳熱的清潔因子灰污監測模型，對鍋爐負荷、燃煤品質、過量空氣系數、各類工質流量、燃煤量和鍋爐熱效率等的波動變化有很好的適應性。以北侖電廠1 #爐歷史庫中數據為輸入數據，驗證了清潔因子模型的正確性和對穩定負荷的適應性。Practice shows the technical renovation has greatly improved thermal efficiency of gas well - type heat treatment furnace, increasing productivity of furnace, achieving objective of saving energy and reducing environmental pollution
實踐表明：技改有效地提高了燃氣井式熱處理爐的熱效率，提高了爐子的產量，達到了節能與減少環境污染的目的。At present, the crystal growth equipment is equipped with vacuum tube hf ( lmhz - 2. 5mhz ) induction heating power supply. while this supply has many disadvantages, such as low reliability, short longevity of vacuum tube, operational safety, low transfer efficiency
目前，用於晶體生長的區熔式單晶爐配套使用的是國外進口或國內生產的真空電子管式高頻感應加熱電源，存在諸如可靠性差、電子管使用壽命短、操作不安全、變換效率低等問題。While this kind of power supply has many disadvantages, such as low reliability, short longevity of vacuum tube, operational safety and low transfer efficiency, existing huge capacity solid induction heating power supply cannot replace them to meet industrial needs
目前，國內用於晶體生長的區熔式單晶爐配套使用的是國外進口或國內生產的真空電子管式高頻感應加熱電源，存在諸如可靠性差、電子管使用壽命短、操作不安全、變換效率低等問題。分享友人