rig tested 中文意思是什麼
-
The degrees of crystallinity of pure ptfe under the different conditions of water cooling, air cooling and furnace - varying cooling were made comparison by xrd. the thermal stability of pure ptfe and solid lubricant was analyzed by dsc - tg ; the composition and valence state of elements in the surface of carbon fiber, solid lubricant before and after friction test and lubricant transfer film were characterized by xps ; the frictional property of solid lubricant was tested by pin and disk test rig. the frictional wear property of solid lubricant between embedded bearing sleeve and steel axle friction pair ring was tested by special simulate test machine, the hardness of solid lubricant was tested by pm ; the compression strength of solid lubricant was tested by material test machine
用sem表徵原料微觀結構、摩擦表面及潤滑轉移膜表面形貌：用xrd進行原料物相分析，及比較水冷卻、空氣冷卻、隨爐冷卻三種工藝條件下的純聚四氟乙烯樹脂的結晶度；用dsc - tg分析純聚四氟乙烯樹脂及固體潤滑劑的熱穩定性；用xps表徵碳纖維表面、固體潤滑劑摩擦前後表面、潤滑轉移膜表面的元素組成、價態變化；用銷盤式摩擦磨損試驗機對固體潤滑劑進行摩擦性能測試；採用專用的臺架模擬試驗機對固體潤滑劑鑲嵌軸承套與鋼軸摩擦副間的摩擦磨損性能進行測定；用萊次偏光顯微鏡（ pm ）測試固體潤滑劑的硬度；用材料試驗機測試固體潤滑劑的抗壓強度等。 -
This paper presents an investigation on a new type of rubber damper, that is, a rubber damper with honeycomb structure. the honeycomb structure will enhance the energy dissipation of a rubber damper and as a result increase the damping of the damper. the performances of honeycomb dampers are experimentally tested by a test rig. the results show that the diameter and the density of holes of the honeycomb structure are important parameters in the design of the damper. for a damper of given size, there are optimum values of both parameters with which the damper provides highest damping. additionally the honeycomb structure does not change the correlation of damping to frequency. a practical honeycomb damper is designe d and applied to inlet pipe of a screw compressor in a petroleum factory for vibration reduction. the vibration of the pipe is obviously suppressed by the damper, at least 25 %
本文採用理論分析和實驗相結合的方法，研究了蜂窩孔這種結構因素對橡膠阻尼材料阻尼性能的影響。在自行設計、製作的懸臂式阻尼測試實驗裝置上，對蜂窩式橡膠阻尼器的阻尼性能進行了大量的實驗測試，初步找出了蜂窩孔孔徑、孔數以及預壓縮量等因素與阻尼器阻尼性能的關系。本文利用實驗研究的結論，設計了一種專用的蜂窩式橡膠阻尼器，並應用於某廠螺桿壓縮機進口管道的減振，取得了明顯的減振效果。
分享友人