高爐渣口 的英文怎麼說
中文拼音 [gāolúzhākǒu]
高爐渣口
英文
cinder monkey-
This article aims at the boiler ' s problems in operation : 1 ) under nominal load, the smoke temperature at the outlet of hearth reaches 1200, far more exceeds 1050 the original designed temperature. this will always result in slag inside boiler and the temperature of overheater ' s pipe superheat, so that boiler cannot take nominal load and all these influence boiler ' s nomal operation heavily, 2 ) this article also studied the reason why the assistant oil becoming necessary when coal changes. during the nomal operation, many factors ( makeup of combustor and its disposal, smirch and encrust of water wall, excessive air coefficient, temperature of primary air, coal type and density of coal dust ) can deviate the designed working conditions, then affect the boiler ' s nomal operation
本文針對該鍋爐在實際運行中存在的問題：在額定負荷下，爐膛出口超溫、低溫段過熱器前煙溫高達936 ，遠遠超過815的設計值；噴燃器四周水冷壁結焦嚴重，過熱器管壁溫度超標，無法帶上額定負荷；甚至有時因燃煤質量的變化，必須投油助燃的嚴重情況進行了分析研究。在實際生產過程中，燃燒器的結構、布置，水冷壁的粘污、結垢，過剩空氣系數、一次風溫、煤種及其濃度變化等許多因素都會偏離鍋爐的設計工況，從而影響爐內的傳熱和燃燒，造成爐膛出口超溫、水冷壁結渣等問題。To solve the frequent ash and slag stacking in the ash - pit under the 600 mw supercritical boiler for huaneng shanghai shidongkou no. 2 power plant, the high resolution acoustics imaging real - time monitoring system was developed using underwater acoustics imaging technology
摘要結合華能上海石洞口二電廠600mw超臨界鍋爐爐底灰坑頻繁堆渣排放的實際情況，利用水下聲納成像技術，開發了高解析度聲納成像實時監視系統。It is widely applied to the stove top, shove head, stove door and burmer brick, the binding of cooling - tube and groove bottom of the molten steel mouth of the heat stove, meantime empopyed in the field of the step stove bottom, the fir - proof wall of the circular stove, the cover, the protruding tape and sand sealing mouth of the equal - heating stove, the triangle, the spray gun and meltingiron groove of electric stove and also including fire - resistant material used in the refine stove and the stove door
加熱爐的爐頂、爐頭、爐門、燒嘴磚、水冷管包紮、出鋼槽槽底、步進爐爐底、環形爐檔火墻、均熱爐的爐蓋、凸出帶、砂封口、中間包包蓋、電爐三角區、鐵水包襯里、爐外精煉用噴槍，底吹氧煙道、鐵水溝蓋、檔渣堰、高爐中各種耐用火料襯里煉焦爐爐門等。A new technology of oxygen - enriched blasting for the first tap of blast furnace has been developed. the blast furnace can be tapped smoothly and operated normally after blast. the accident of tap failure, followed by tuyere burning due to slag going up can be avoided
利用富氧燃燒技術研究一種高爐首次出鐵時吹燒鐵口新工藝，使休風后的高爐出鐵順利，盡快達到高爐順行，避免鐵水出不來，爐內渣面上漲，風口燒穿等事故的發生。Abstract : a new technology of oxygen - enriched blasting for the first tap of blast furnace has been developed. the blast furnace can be tapped smoothly and operated normally after blast. the accident of tap failure, followed by tuyere burning due to slag going up can be avoided
文摘:利用富氧燃燒技術研究一種高爐首次出鐵時吹燒鐵口新工藝，使休風后的高爐出鐵順利，盡快達到高爐順行，避免鐵水出不來，爐內渣面上漲，風口燒穿等事故的發生。分享友人