結垢因數 的英文怎麼說
中文拼音 [jiēgòuyīnshǔ]
結垢因數
英文
fluling factor-
This article aims at the boiler ' s problems in operation : 1 ) under nominal load, the smoke temperature at the outlet of hearth reaches 1200, far more exceeds 1050 the original designed temperature. this will always result in slag inside boiler and the temperature of overheater ' s pipe superheat, so that boiler cannot take nominal load and all these influence boiler ' s nomal operation heavily, 2 ) this article also studied the reason why the assistant oil becoming necessary when coal changes. during the nomal operation, many factors ( makeup of combustor and its disposal, smirch and encrust of water wall, excessive air coefficient, temperature of primary air, coal type and density of coal dust ) can deviate the designed working conditions, then affect the boiler ' s nomal operation
本文針對該鍋爐在實際運行中存在的問題：在額定負荷下，爐膛出口超溫、低溫段過熱器前煙溫高達936 ，遠遠超過815的設計值；噴燃器四周水冷壁結焦嚴重，過熱器管壁溫度超標，無法帶上額定負荷；甚至有時因燃煤質量的變化，必須投油助燃的嚴重情況進行了分析研究。在實際生產過程中，燃燒器的結構、布置，水冷壁的粘污、結垢，過剩空氣系數、一次風溫、煤種及其濃度變化等許多因素都會偏離鍋爐的設計工況，從而影響爐內的傳熱和燃燒，造成爐膛出口超溫、水冷壁結渣等問題。Enhanced heat transfer tube with spiral - surface has simple frame, cheap cost, and wide - ranging purpose. only few dirt can adhere to it and is easy to be washed. it has distinct strengthen effect, and can improve chief heat transfer coefficient at 35 - 40 % comparing with smooth tube exchanger which has same volume and pump power consumption
螺旋型表面強化管結構簡單，成本低廉，用途廣泛，結垢少且易清洗，其強化效果明顯，與體積、消耗泵功率相同的光管式換熱器相比，螺旋槽管換熱器可以將總傳熱系數提高35 40 ，因而備受人們青睞。
分享友人