mullite 中文意思是什麼

mullite 解釋
（耐高溫材料） 富鋁紅柱石
  1. Cordierite - mullite kiln furniture

    莫來石窯具
  2. In early 1993, dr. peter put forward an idea that it is possible to substitute gahnite for mullite used as the raw material for ceramic cup of blast furnace

    早在1993年， peter博士曾提出鋅鋁尖晶石有可能作為制備高爐陶瓷杯的原料以替代莫來石。
  3. Study on the synthesis of corundum - mullite - gahnite multiphase materials by one - step sintering process using kaolinite showed that corundum - mullite - gahnite multiphase materials with the apparent porosity less than 5 % can be obtained through sintering at 1700 for 3h

    在1700下保溫3h ，能夠一步合成出顯氣孔率在5以下的剛玉?莫來石?鋅鋁尖晶石復相材料，各物相間結合緊密，發育較好。
  4. The formation of new phase such as mullite and gahnite by solid - phase reaction in multiphase materials can benefit the sintering of materials at 1700, decreased apparent porosity to less than 5 %. reducing atmosphere inhibited the synthesis of mullite and gahnite, played a negative role in the densification of multiphase materials

    固相反應生成的鋅鋁尖晶石和莫來石具有較高的活性，使復相材料在1700燒后顯示出更好的燒結性能，其顯氣孔率降低到5以下；還原性氣氛阻礙了莫來石和鋅鋁尖晶石的生成，不利於復相材料的燒結和緻密化。
  5. Study on the synthesis of corundum - mullite - gahnite multiphase materials by two - step sintering process using kaolinite as raw material showed that impurities introduced by kaolinite mainly increased the liquid amount at high temperature, which can assist sintering of specimen. the experiment results indicated that the samples with lower gahnite content had better sinterability than others. however, if the gahnite content was relative high, the promoting effect on sinterability caused by kaolinite was not significant

    採用天然原料高嶺土二步煅燒合成剛玉?莫來石?鋅鋁尖晶石復相材料研究發現：天然原料中帶入的雜質主要是增加液相量，促進高溫下試樣的燒結；當尖晶石含量較低時，試樣在1300保溫2h時，在1600燒后試樣燒結性能相比之下較好；而當鋅鋁尖晶石含量較高時，天然料對試樣的促燒作用不是非常明顯。
  6. Based on orthogonal designed experiment, the synthesis of corundum - mullite - gahnite multiphase materials by two - step sintering process showed that the light fired temperature and holding time mostly influenced the apparent porosity of the multiphase materials. further study on the light firing time indicated that at the light firing temperature of 1300 and died fire temperature of 1600 for 3h, the optimal light fired time was about 1h

    二次煅燒及正交實驗合成復相材料研究表明：輕燒溫度和輕燒時間對復相材料的顯氣孔率影響顯著；通過輕燒保溫時間的進一步研究表明：含剛玉、莫來石、鋅鋁尖晶石的復相材料，在輕燒溫度為1300 、終燒條件為1600下保溫3h時，最佳的保溫時間為1小時左右。
  7. Based on the review, the main objectives of this work had been determined. the thermodynamic analysis indicated that corundum - mullite - gahnite multiphase materials can be synthesized. the investigation of x - ray diffraction ( xrd ) and scan electron microscope ( sem ) proved the validity of thermodynamics research

    通過對al _ 2o _ 3 - sio _ 2 - zno體系相關反應熱力學的計算表明能夠合成出剛玉?莫來石?鋅鋁尖晶石復相材料， x ?射線衍射（ xrd ）和掃描電子顯微鏡（ sem ）的研究證實了熱力學計算的可靠性。
  8. It is well known that there exists a composition triangle in phase diagram for ternary system of al2o3 - sio2 - zno, responding to three high temperature phases of corundum, mullite and gahnite. through control of chemical composition and technical process, it is possible to synthesize corundum - mullite - gahnite multiphase materials theoretically

    在al _ 2o _ 3 - sio _ 2 - zno三元系中，存在著一個對應剛玉、莫來石和鋅鋁尖晶石三物相的分三角形，在適當的配料組成和工藝條件下，是能夠合成出剛玉?莫來石?鋅鋁尖晶石復相材料。
  9. Study on the synthesis of corundum - mullite - gahnite multiphase materials by one - step sintering process using high purity raw materials showed that the more the content of gahnite in multiphase materials, the high the volume expansion would be introduced in the system, which resulted in the sintering difficulty of the multiphase materials. while the content of gahnite was controlled about 30wt % and the content of mullite was about 70wt %, the densified multiphase materials can be obtained after fired at 1600 or 1700

    採用高純原料一步合成剛玉?莫來石?鋅鋁尖晶石復相材料研究表明：復相材料中鋅鋁尖晶石含量越高，則合成鋅鋁尖晶石時產生的體積膨脹越大，燒結性也就越差；當鋅鋁尖晶石含量為30wt ，莫來石含量較高為70wt左右時，在1600或1700燒后都能得到顯微結構較為緻密的復相材料。
  10. The key products of the company are high alumina brick, fireclay brick, phosphate - bonded wearable brick, exfoliation - resistant high alumina brick, high refractoriness under load brick, corundum brick, magnesite brick, magnesite ? chrome brick, series of corundum, sic furnace chamber and pipe, ceramisite brick, corundum - mullite brick, corundum - chrome brick, sillimanite brick, magnesite alumina spinel brick, acid - resistant brick, alkali - resistant brick, zirconia - corundum brick, alumina bubble products, series thermal insulating refractory products, high alumina castable, corundum castable, corundum ramming, brown - corundunm castable, sic castable, low - cement castable, alkali ? resistant castable, light silica alumina products, stainless steel fibre reinforced castable, etc

    主要產品有：高鋁質磚、粘土質磚、磷酸鹽耐磨磚、抗剝落磚、高荷軟磚、剛玉磚、碳化硅磚、鎂磚、鎂鉻磚、各種剛玉、 sic爐膛、爐管製品、陶粒磚、剛玉莫來石磚、鉻剛玉磚、硅線石磚、鎂鉻尖晶石磚、耐酸磚、耐堿磚、鋯剛玉磚、氧化鋁空心球製品及各種輕質保溫材料、高鋁質澆注料和剛玉澆注料、搗打料、棕剛玉澆注料、碳化硅澆注料，低水泥澆注料、抗堿性澆注料、輕質硅酸鋁製品、鋼纖維增強澆注料等80餘種系列耐火材料。
  11. This paper introduces that the diffuse heat heating furnace is reduced the consumption of fuel is debased and the preferable effect is got, using the multicrystal mullite fibrous stickup lump to heat preservation in heating furnace wall

    摘要採用多晶莫來石纖維貼面塊對加熱爐爐內壁保溫，減少了爐體的散熱損失，降低了爐子燃耗，取得了較好的效果。
  12. ( 1 ) how to prefabricate mullite whisker formed in - site to enhance ceramics intensity, improve thermal - shock resistance by adoption zirconate and alumina to sinter mullite / zirconia / alumina composite ceramics. ( 2 ) studying on the plasticity of high alumina body materials

    利用氧化鋁、鋯英石原料燒成氧化鋁氧化鋯莫來石復合陶瓷，通過原位生成莫來石晶須提高載體的強度、改善其抗熱震性。
  13. Used for corundum bricks, mullite bricks, silicate bricks masonry in blast furnaces, hot air stoves

    用於高爐、熱風爐砌築剛玉磚、莫來石磚、硅線石磚、低蠕變高鋁磚。
  14. Standard classification of mullite refractories

    富鋁紅柱石耐火材料的標準分類
  15. Kiln guiding - rail bricks, supporting suspension bricks and ultra - thin extruded batts are recently developed for the phenomenon of pollution and pulverization caused by using insulation bricks or high - temperature refractory wool in the kilns. they are made from cordierite and mullite with a high strength. they can cover the kiln wall structure made of refractory fiber, greatly reduce pollution and pulverization, remarkably save the energy, easy to be constructed on worksite, and the aspect is beautiful and novel. they are ideal material for large - scale shuttle - kiln or computerized puadrate kiln

    窯體道軌磚及支撐吊磚和超薄中空板是針對目前窯爐採用傳統耐火材料在使用過程中由於組多原因造成落臟或粉化現象而開發生產；它是堇青石-莫來石材料製造而成，強度大，熱穩定性佳、覆蓋耐火纖維製品組成窯爐墻體結構，它能大大減輕落臟與粉化現象，節能效果十分明顯、施工方便、整體美觀新超是高級大型梭式或電腦方窯等窯爐的理想材料。
  16. Our factory adopted high pure electric smelting mullite as main material, which is produced new size the best refuactory throught heat pressure and tem - - perature burning, it is suital ble for steel and ion, metallurgy and ceramics and is special suitable for stove top. stove wall and heat temper ature posmon of hot wind stove

    我廠採用高純電熔莫來石做主要原料經高壓成型和高溫燒成而制得的低蠕變磚是一種新型的高級耐火材料，適用於鋼鐵，冶金和陶瓷等行業，特別適用於熱風爐的頂爐墻及各高溫部位。
  17. Preparation of mullite sol and mullite sol coated aluminum titanate powder

    莫來石溶膠的制備及對鈦酸鋁粉體的包裹
  18. The main products including the high quality cordierite raw materials and low - al2o3 mullite raw materials for manufacture of high performance mullite - cordierite kiln furniture, mullite - cordierite extruded batts, flat batts, perforated batts, grooved batts, many kinds of supports etc

    主要產品有：高溫合成的低鋁莫來石和堇青石原料，莫來石-堇青石質的中空棚板，平板，多孔板，溝槽板，各種支柱及異型支架等系列窯具。
  19. In the process of preparing mullite powder, we use teos and al ( no3 ) 3 as raw materials. the powder we prepared has high purity and its grain radius is relatively small and is distributed equality. by this method, we prepared about 600 g mullite powder and it provided basis for the next experiment

    在溶膠-凝膠法制備莫來石粉末過程中，我們以正硅酸乙酯和硝酸鋁為主要原料，採用該法制得了莫來石粉末，該粉末純度很高，粒徑較小並且分佈均勻，我們按該法制得了約600g莫來石粉料，為接下來的實驗打下了基礎。
  20. Abstract : this paper dicussed the preparative parameteres synthesized mullite ultrafine powder by sol - gel and co2 scfd ( supercritieal fluid drying ) method from teos and al ( no3 ) 3 ? 9h2o as raw materials. the control parameteres of the colloidal particle size forming in sol - gel process and the gel structure and the scfd were studied by, xrd, tem and bet techmiques

    文摘:研究了以正硅酸乙酯和硝酸鋁為原料，採用溶膠一凝膠法結合co2超臨界流體低溫乾燥技術合成莫來石超細粉的制備參數控制，並利用xrd 、 tem和bet 、技術研究了溶膠-凝膠過程中溶膠膠粒大小的控制和凝膠結構的控制及超臨界流體乾燥技術的控制。
分享友人
分享到 Line

分享到臉書